PubMed İndeksli Yayınlar Koleksiyonu / PubMed Indexed Publications Collection
Permanent URI for this collectionhttps://hdl.handle.net/11147/7645
Browse
6 results
Search Results
Now showing 1 - 6 of 6
Article Citation - WoS: 18Citation - Scopus: 35Microparticle-Enhanced Polygalacturonase Production by Wild Type Aspergillus Sojae(Springer Verlag, 2017) Karahalil, Ercan; Demirel, Fadime; Evcan, Ezgi; Germeç, Mustafa; Tarı, Canan; Turhan, İrfanPolygalacturonases (PGs), an important industrial enzyme group classified under depolymerases, catalyze the hydrolytic cleavage of the polygalacturonic acid chain through the introduction of water across the oxygen bridge. In order to produce and increase the concentration of this enzyme group in fermentation processes, a new approach called microparticle cultivation, a promising and remarkable method, has been used. The aim of this study was to increase the PG activity of Aspergillus sojae using aluminum oxide (Al2O3) as microparticles in shake flask fermentation medium. Results indicated that the highest PG activity of 34.55 ± 0.5 U/ml was achieved with the addition of 20 g/L of Al2O3 while the lowest activity of 15.20 ± 0.2 U/mL was obtained in the presence of 0.1 g/L of Al2O3. In fermentation without microparticles as control, the activity was 15.64 ± 3.3 U/mL. Results showed that the maximum PG activity was 2.2-fold higher than control. Additionally, smaller pellets formed with the addition of Al2O3 where the lowest pellet diameter was 955.1 µm when 10 g/L of the microparticle was used. Also, it was noticed that biomass concentration gradually increased with increasing microparticle concentration in the fermentation media. Consequently, the PG activity was significantly increased in microparticle-enhanced shake flask fermentation. In fact, these promising preliminary data can be of significance to improve the enzyme activity in large-scale bioreactors.Article Citation - WoS: 13Citation - Scopus: 18Effect of Physicochemical Parameters on the Polygalacturonase of an Aspergillus Sojae Mutant Using Wheat Bran, an Agro-Industrial Waste, Via Solid-State Fermentation(John Wiley and Sons Inc., 2016) Demir, Hande; Tarı, CananBACKGROUND: Polygalacturonases (PGs) are valuable enzymes of the food industry; therefore it is of great importance to discover new and GRAS PG-producing microbial strains. In this study, PG enzyme produced from a high PG activity producer mutant Aspergillus sojae using wheat bran at the flask scale under pre-optimized conditions of solid-state fermentation (SSF) was biochemically characterized. RESULTS: The crude PG enzyme showed optimum activity in the pH range 4.0–5.0 and was stable in the pH range 3.0–7.0. The optimum temperature for the PG was 40 °C and it retained 99% of its activity at 50 °C. The mutant A. sojae PG could preserve more than 50% of its stability between 25 and 50 °C, both for 30 and 60 min, and was found to be stable in the presence of most of the tested compounds and metal ions. The inactivation energy (Ed) was determined as 125.3 kJ mol−1. The enthalpy (ΔH*), free energy (ΔG*) and entropy (ΔS*) of inactivation were found to be stable with increasing temperature. CONCLUSION: The mutant A. sojae PG could be suitable for the clarification (depectinization) of orange and grape juices and wine. © 2015 Society of Chemical Industry.Article Citation - WoS: 12Citation - Scopus: 16Utilization of Orange Peel, a Food Industrial Waste, in the Production of Exo-Polygalacturonase by Pellet Forming Aspergillus Sojae(Springer Verlag, 2015) Büyükkileci, Ali Oğuz; Lahore, Marcelo Fernandez; Tarı, CananThe production of exo-polygalacturonase (exo-PG) from orange peel (OP), a food industrial waste, using Aspergillus sojae was studied in submerged culture. A simple, low-cost, industrially significant medium formulation, composed of only OP and (NH4)2SO4 (AS) was developed. At an inoculum size of 2.8 × 103 spores/mL, growth was in the form of pellets, which provided better mixing of the culture broth and higher exo-PG activity. These pellets were successfully used as an inoculum for bioreactors and 173.0 U/mL exo-PG was produced. Fed-batch cultivation further enhanced the exo-PG activity to 244.0 U/mL in 127.5 h. The final morphology in the form of pellets is significant to industrial fermentation easing the subsequent downstream processing. Furthermore, the low pH trend obtained during this fermentation serves an advantage to fungal fermentations prone to contamination problems. As a result, an economical exo-PG production process was defined utilizing a food industrial by-product and producing high amount of enzyme.Article Citation - WoS: 3Citation - Scopus: 4Evaluation of Agro-Industrial Wastes, Their State, and Mixing Ratio for Maximum Polygalacturonase and Biomass Production in Submerged Fermentation(Taylor and Francis Ltd., 2015) Göğüş, Nihan; Evcan, Ezgi; Tarı, Canan; Cavalitto, Sebastian F.The potential of important agro-industrial wastes, apple pomace (AP) and orange peel (OP) as C sources, was investigated in the maximization of polygalacturonase (PG), an industrially significant enzyme, using an industrially important microorganism Aspergillus sojae. Factors such as various hydrolysis forms of the C sources (hydrolysed-AP, non-hydrolysed-AP, hydrolysed-AP + OP, non-hydrolysed-AP + OP) and N sources (ammonium sulphate and urea), and incubation time (4, 6, and 8 days) were screened. It was observed that maximum PG activity was achieved at a combination of non-hydrolysed-AP + OP and ammonium sulphate with eight days of incubation. For the pre-optimization study, ammonium sulphate concentration and the mixing ratios of AP + OP at different total C concentrations (9, 15, 21 g-1) were evaluated. The optimum conditions for the maximum PG production (144.96 ml-1) was found as 21 g-1 total carbohydrate concentration totally coming from OP at 15 g-1 ammonium sulphate concentration. On the other hand, 3:1 mixing ratio of OP + AP at 11.50 g-1 ammonium sulphate concentration also resulted in a considerable PG activity (115.73 ml-1). These results demonstrated that AP can be evaluated as an additional C source to OP for PG production, which in turn both can be alternative solutions for the elimination of the waste accumulation in the food industry with economical returns.Article Citation - WoS: 29Citation - Scopus: 29Microbial Strain Improvement for Enhanced Polygalacturonase Production by Aspergillus Sojae(Springer Verlag, 2014) Heerd, Doreen; Tarı, Canan; Fernandez Lahore, MarceloStrain improvement is a powerful tool in commercial development of microbial fermentation processes. Strains of Aspergillus sojae which were previously identified as polygalacturonase producers were subjected to the cost-effective mutagenesis and selection method, the so-called random screening. Physical (ultraviolet irradiation at 254 nm) and chemical mutagens (N-methyl-N′-nitro-N-nitrosoguanidine) were used in the development and implementation of a classical mutation and selection strategy for the improved production of pectic acid-degrading enzymes. Three mutation cycles of both mutagenic treatments and also the combination of them were performed to generate mutants descending from A. sojae ATCC 20235 and mutants of A. sojae CBS 100928. Pectinolytic enzyme production of the mutants was compared to their wild types in submerged and solid-state fermentation. Comparing both strains, higher pectinase activity was obtained by A. sojae ATCC 20235 and mutants thereof. The highest polygalacturonase activity (1,087.2±151.9 U/g) in solid-state culture was obtained by mutant M3, which was 1.7 times increased in comparison to the wild strain, A. sojae ATCC 20235. Additional, further mutation of mutant M3 for two more cycles of treatment by UV irradiation generated mutant DH56 with the highest polygalacturonase activity (98.8±8.7 U/mL) in submerged culture. This corresponded to 2.4-fold enhanced polygalacturonase production in comparison to the wild strain. The results of this study indicated the development of a classical mutation and selection strategy as a promising tool to improve pectinolytic enzyme production by both fungal strains.Article Citation - WoS: 52Citation - Scopus: 62Solid-State Production of Polygalacturonase by Aspergillus Sojae Atcc 20235(Elsevier Ltd., 2007) Üstok, Fatma Işık; Tarı, Canan; Göğüş, NihanThe effect of solid substrates, inoculum and incubation time were studied using response surface methodology (RSM) for the production of polygalacturonase enzyme and spores in solid-state fermentation using Aspergillus sojae ATCC 20235. Two-stage optimization procedure was applied using D-optimal and face-centered central composite design (CCD). Crushed maize was chosen as the solid substrate, for maximum polygalacturonase enzyme activity based on D-optimal design. Inoculum and incubation time were determined to have significant effect on enzyme activity and total spore (p < 0.01) based on the results of CCD. A second order polynomial regression model was fitted and was found adequate for individual responses. All two models provided an adequate R2 of 0.9963 (polygalacturonase) and 0.9806 (spores) (p < 0.001). The individual optimum values of inoculum and incubation time for maximum production of the two responses were 2 × 107 total spores and 5-6 days. The predicted enzyme activity (30.55 U/g solid) and spore count (2.23 × 107 spore/ml) were very close to the actual values obtained experimentally (29.093 U/g solid and 2.31 × 107 spore/ml, respectively). The overall optimum region considering the two responses together, overlayed with the individual optima. Solid-state fermentation provided 48% more polygalacturonase activity compared to submerged fermentation under individually optimized conditions.